| Common Name: | WELDWOOD MULTI-PURPOSE FLOOR ADHESIVE |
| Manufacturer: | DAP |
| SDS Revision Date: | 6/19/2015 |
| SDS Format: | GHS-US |
| Grainger Item Number(s): | 2PE38 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SDS NUMBER: 00030807001
REVISION DATE: 6/19/2015
DAP(R*)
SAFETY DATA SHEET
24 HOUR EMERGENCY PHONE NUMBERS:
MEDICAL/POISON CONTROL:
IN U.S.:
CALL: 1-800-222-1222
OUTSIDE U.S.: CALL YOUR LOCAL POISON CONTROL CENTER
TRANSPORTATION/NATIONAL RESPONSE CENTER:
1-800-535-5053
1-352-323-3500
NOTE:
THE NATIONAL RESPONSE CENTER EMERGENCY NUMBERS TO BE USED ONLY IN THE EVENT
OF CHEMICAL EMERGENCIES INVOLVING A SPILL, LEAK, FIRE, EXPOSURE OR ACCIDENT
INVOLVING CHEMICALS.
IMPORTANT:
PROVIDE THIS INFORMATION TO EMPLOYEES, CUSTOMERS, AND USERS OF THIS
PRODUCT. READ THIS SDS BEFORE HANDLING OR DISPOSING OF THIS PRODUCT. THIS
PRODUCT IS COVERED BY THE OSHA HAZARD COMMUNICATION STANDARD AND THIS
DOCUMENT HAS BEEN PREPARED IN ACCORDANCE WITH REQUIREMENTS OF THIS
STANDARD. ALL ABBREVIATED TERMS USED IN THIS MSDS ARE FURTHER DESCRIBED
IN SECTION 16.
| 1. IDENTIFICATION |  |
THIS MATERIAL SAFETY DATA SHEET IS AVAILABLE IN AMERICAN SPANISH UPON
REQUEST.
PRODUCT NAME: DAP WELDWOOD MULTI-PURPOSE FLOOR ADHESIVE
PRODUCT UPC NUMBER: 00144, 00142, 00141, 00151
PRODUCT USE/CLASS: CONSTRUCTION ADHESIVE
REVISION DATE: 6/19/2015
SUPERCEDES DATE: 4/3/2012
SDS NO: 00030807001
MANUFACTURER:
DAP PRODUCTS INC.
2400 BOSTON STREET
SUITE 200
BALTIMORE, MD 21224-4723
888-327-8477 (NON - EMERGENCY MATTERS)
PREPARER: REGULATORY DEPARTMENT
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
MAY CAUSE EYE, SKIN, NOSE, THROAT AND RESPIRATORY TRACT IRRITATION. THIS
PRODUCT CONTAINS ETHYLENE GLYCOL.
GHS CLASSIFICATION: SKIN SENS. 1
SYMBOL(S) OF PRODUCT: EXCLAMATION MARK
SIGNAL WORD: WARNING
GHS HAZARD STATEMENTS:
SKIN SENSITIZER, CATEGORY 1:
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
GHS LABEL PRECAUTIONARY STATEMENTS:
P261: AVOID BREATHING DUST/FUME/GAS/MIST/VAPOURS/SPRAY.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P302+P352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P333+P313:
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
GHS SDS PRECAUTIONARY STATEMENTS:
P363: WASH CONTAMINATED CLOTHING BEFORE REUSE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
CHEMICAL NAME CAS-NO. WT. % GHS SYMBOLS GHS STATEMENTS
CLAY 1332-58-7 25-50 GHS03 H270
PETROLEUM 64742-52-5 10-25 GHS03 H270
HYDROCARBON OIL
UREA 57-13-6 2.5-10 GHS03 H270
ROSIN 8050-09-7 1.0-2.5 GHS03-GHS07 H270-317-332
ETHYLENE GLYCOL 107-21-1 1.0-2.5 GHS03-GHS06 H270-331
TITANIUM DIOXIDE 13463-67-7 0.1-1.0 NO INFORMATION NO INFORMATION
THE TEXT FOR GHS HAZARD STATEMENTS SHOWN ABOVE (IF ANY) IS GIVEN IN THE
"OTHER INFORMATION" SECTION.
| 4. FIRST-AID MEASURES | |
FIRST AID - INHALATION:
IF YOU EXPERIENCE DIFFICULTY IN BREATHING, LEAVE THE AREA TO OBTAIN FRESH
AIR. IF CONTINUED DIFFICULTY IS EXPERIENCED, GET MEDICAL ATTENTION
IMMEDIATELY.
FIRST AID - SKIN CONTACT:
IN CASE OF CONTACT, WASH SKIN IMMEDIATELY WITH SOAP AND WATER.
FIRST AID - EYE CONTACT:
IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH LARGE QUANTITIES OF WATER
FOR AT LEAST 15 MINUTES UNTIL IRRITATION SUBSIDES. GET MEDICAL ATTENTION
IMMEDIATELY.
FIRST AID - INGESTION:
IF SWALLOWED, DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION IMMEDIATELY.
| 5. FIRE-FIGHTING MEASURES | |
UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE KNOWN.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND (NIOSH APPROVED
OR EQUIVALENT) AND FULL PROTECTIVE GEAR. USE WATER SPRAY TO COOL EXPOSED
SURFACES.
EXTINGUISHING MEDIA: CARBON DIOXIDE, DRY CHEMICAL, FOAM
| 6. ACCIDENTAL RELEASE MEASURES | |
ENVIRONMENTAL MEASURES: NO INFORMATION
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
CONTAIN SPILLED MATERIAL AND REMOVE WITH INERT ABSORBENT. DISPOSE OF
CONTAMINATED ABSORBENT, CONTAINER AND UNUSED CONTENTS IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. SCRAPE UP DRIED MATERIAL AND PLACE
INTO CONTAINERS. USE PERSONAL PROTECTIVE EQUIPMENT AS NECESSARY. IN CASE OF
SPILLAGE, ABSORB WITH INERT MATERIAL AND DISPOSE OF IN ACCORDANCE WITH
APPLICABLE REGULATIONS.
| 7. HANDLING AND STORAGE | |
HANDLING:
KEEP OUT OF REACH OF CHILDREN!
DO NOT TAKE INTERNALLY.USE ONLY WITH ADEQUATE VENTILATION. ENSURE FRESH
AIR ENTRY DURING APPLICATION AND DRYING. AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. WASH THOROUGHLY AFTER HANDLING. CONSTRUCTION AND REPAIR
ACTIVITIES CAN ADVERSELY AFFECT INDOOR AIR QUALITY. CONSULT WITH OCCUPANTS
OR A REPRESENTATIVE (I.E. MAINTENANCE, BUILDING MANAGER, INDUSTRIAL
HYGIENIST, OR SAFETY OFFICER) TO DETERMINE WAYS TO MINIMIZE IMPACT. DO NOT
SAND, DRY SWEEP, DRY SCRAPE, DRILL, SAW, BEADBLAST, MECHANICALLY CHIP,
PULVERIZE OR OTHERWISE MACHINE EXISTING RESILIENT FLOORING, BACKING,
LINING FELT, OR ASPHALTIC "CUT-BACK" ADHESIVES. THESE PRODUCTS MAY CONTAIN
EITHER ASBESTOS FIBERS OR CRYSTALLINE SILICA. AVOID CREATING DUST.
INHALATION OF SUCH DUST IS A CANCER AND RESPIRATORY TRACT HAZARD. SEE
CURRENT EDITION OF THE RESILIENT FLOOR COVERING INSTITUTE'S PUBLICATION
"RECOMMENDED WORK PRACTICES FOR REMOVAL OF RESILIENT FLOOR COVERINGS",
FOR DETAILED INFORMATION AND INSTRUCTIONS ADDRESSED TO THE TASK OF
REMOVING ALL RESILIENT FLOOR COVERING MATERIALS.
STORAGE:
AVOID EXCESSIVE HEAT AND FREEZING. DO NOT STORE AT TEMPERATURES ABOVE 120
DEGREES F. STORE AWAY FROM CAUSTICS AND OXIDIZERS. KEEP CONTAINERS TIGHTLY
CLOSED.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
INGREDIENTS WITH OCCUPATIONAL EXPOSURE LIMITS:
CHEMICAL NAME ACGIH ACGIH- OSHA OSHA
TLV-TWA TLV STEL PEL-TWA PEL-CEILING
CLAY 2 MG/M3 TWA N.E. 15 MG/M3 TWA N.E.
PARTICULATE TOTAL DUST
MATTER
CONTAINING 5 MG/M3 TWA
NO ASBESTOS RESPIRABLE
AND <1% FRACTION
CRYSTALLINE
SILICA,
RESPIRABLE
FRACTION
PETROLEUM N.E. N.E. N.E. N.E.
HYDROCARBON
OIL
UREA N.E. N.E. N.E. N.E.
ROSIN N.E. N.E. N.E. N.E.
ETHYLENE GLYCOL N.E. N.E. N.E. N.E.
TITANIUM 10 MG/M3 N.E. 15 MG/M3 TWA N.E.
DIOXIDE TWA TOTAL DUST
FURTHER ADVICE:
MEL = MAXIMUM EXPOSURE LIMIT
OES = OCCUPATIONAL EXPOSURE STANDARD
SUP = SUPPLIER'S RECOMMENDATION
SK = SKIN SENSITIZER
N.E. = NOT ESTABLISHED
PERSONAL PROTECTION:
RESPIRATORY PROTECTION:
RESPIRATOR USE IS NOT EXPECTED TO BE NECESSARY UNDER NORMAL CONDITIONS OF
HANDLING. IN EMERGENCY SITUATIONS, USE OF A NIOSH-APPROVED RESPIRATOR MAY
BE REQUIRED. A RESPIRATORY PROTECTION PROGRAM THAT MEETS THE OSHA 1910.134
AND ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS
WARRANT A RESPIRATOR'S USE.
SKIN PROTECTION: WEAR RUBBER GLOVES.
EYE PROTECTION: GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS.
OTHER PROTECTIVE EQUIPMENT: NOT REQUIRED UNDER NORMAL USE.
HYGIENIC PRACTICES:
WASH HANDS BEFORE BREAKS AND AT THE END OF WORKDAY. REMOVE AND WASH
CONTAMINATED CLOTHING BEFORE RE-USE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: WHITE TO OFF-WHITE
PHYSICAL STATE: PASTE
ODOR: VERY SLIGHT AMMONIA
ODOR THRESHOLD: NOT ESTABLISHED
DENSITY, G/CM3: 1.21 - 1.21
PH: BETWEEN 7.0 AND 12.0
FREEZE POINT, DEG. C: NOT ESTABLISHED
VISCOSITY (MPA.S): NOT ESTABLISHED
SOLUBILITY IN WATER: NOT ESTABLISHED
PARTITION COEFF., N-OCTANOL/WATER: NOT ESTABLISHED
DECOMPOSITION TEMPERATURE, DEG. C: NOT ESTABLISHED
EXPLOSIVE LIMITS, %: N.I. - N.I.
BOILING RANGE, DEG. C: N.I. - N.I.
AUTO-IGNITION TEMPERATURE, DEG. C: NOT ESTABLISHED
MINIMUM FLASH POINT, DEG. C: 93.3
VAPOR PRESSURE, MMHg: NO INFORMATION
EVAPORATION RATE: SLOWER THAN N-BUTYL ACETATE
FLASH METHOD: SETA CLOSED CUP
VAPOR DENSITY: HEAVIER THAN AIR
COMBUSTIBILITY: DOES NOT SUPPORT COMBUSTION
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
(IF PRODUCT IS AN AEROSOL, THE FLASH POINT STATED ABOVE IS THAT OF THE
PROPELLANT.)
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER RECOMMENDED STORAGE CONDITIONS.
CONDITIONS TO AVOID: EXCESSIVE HEAT AND FREEZING.
INCOMPATIBILITY: INCOMPATIBLE WITH STRONG BASES AND OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NORMAL DECOMPOSITION PRODUCTS, I.E., COX, NOX.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECT OF OVEREXPOSURE - INHALATION:
VAPORS MAY BE IRRITATING TO EYES, NOSE, THROAT, AND LUNGS. INHALATION OF
VAPORS IN HIGH CONCENTRATION MAY CAUSE MILD IRRITATION OF RESPIRATORY
SYSTEM (NOSE, MOUTH, MUCOUS MEMBRANES).
EFFECT OF OVEREXPOSURE - SKIN CONTACT:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEALTH EFFECTS. PROLONGED OR REPEATED CONTACT WITH SKIN MAY CAUSE MILD
IRRITATION.
EFFECT OF OVEREXPOSURE - EYE CONTACT:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEALTH EFFECTS. DIRECT EYE CONTACT MAY CAUSE IRRITATION.
EFFECT OF OVEREXPOSURE - INGESTION:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEALTH EFFECTS. SINGLE DOSE ORAL TOXICITY IS VERY LOW. AMOUNTS INGESTED
INCIDENTAL TO INDUSTRIAL HANDLING ARE NOT LIKELY TO CAUSE INJURY; HOWEVER,
INGESTION OF LARGE AMOUNTS MAY CAUSE INJURY. INGESTION OF ETHYLENE GLYCOL
CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, DIARRHEA AND IF
INGESTED IN SUFFICIENT QUANTITIES, DEATH.
CARCINOGENICITY: NO INFORMATION
PRIMARY ROUTE(S) OF ENTRY: INHALATION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
1332-58-7 CLAY >5000 MG/KG >5000 MG/KG >20 MG/L
RAT RAT
64742-52-5 PETROLEUM 5000 MG/KG 5000 MG/KG <5.7 MG/L RAT
HYDROCARBON RAT RABBIT
OIL
57-13-6 UREA 8471 MG/KG N.I. N.I.
RAT
8050-09-7 ROSIN >5000 MG/KG >2500 MG/KG >20 MG/L
RAT RABBIT
107-21-1 ETHYLENE GLYCOL 4000 MG/KG 9530 MG/KG >2.5 MG/L RAT
RAT RABBIT
13463-67-7 TITANIUM DIOXIDE >10000 MG/KG >5000 MG/KG >20 MG/L
RAT RABBIT
N.I. = NO INFORMATION
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION:
ECOLOGICAL INJURIES ARE NOT KNOWN OR EXPECTED UNDER NORMAL USE.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
THIS PRODUCT DOES NOT MEET THE DEFINITION OF A HAZARDOUS WASTE ACCORDING TO
U.S. EPA HAZARDOUS WASTE MANAGEMENT REGULATION, 40 CFR SECTION 261. DISPOSE
AS HAZARDOUS WASTE ACCORDING TO ALL LOCAL, STATE, FEDERAL AND PROVINCIAL
REGULATIONS. STATE AND LOCAL REGULATIONS/RESTRICTIONS ARE COMPLEX AND MAY
DIFFER FROM FEDERAL REGULATIONS. RESPONSIBILITY FOR PROPER WASTE DISPOSAL
IS WITH THE OWNER OF THE WASTE.
| 14. TRANSPORT INFORMATION | |
SPECIAL TRANSPORT PRECAUTIONS: NO INFORMATION
DOT UN/NA NUMBER: N.A.
DOT PROPER SHIPPING NAME: NOT REGULATED.
DOT TECHNICAL NAME: N.A.
DOT HAZARD CLASS: N.A.
HAZARD SUBCLASS: N.A.
PACKING GROUP: N.A.
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
ACUTE HEALTH HAZARD, CHRONIC HEALTH HAZARD
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
CHEMICAL NAME CAS-NO.
ETHYLENE GLYCOL 107-21-1
TOXIC SUBSTANCES CONTROL ACT:
ALL INGREDIENTS IN THIS PRODUCT ARE EITHER ON TSCA INVENTORY LIST, OR
OTHERWISE EXEMPT.
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
NO TSCA 12(B) COMPONENTS EXIST IN THIS PRODUCT.
CALIFORNIA PROPOSITION 65 CARCINOGENS:
WARNING:
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
CALIFORNIA PROPOSITION 65 REPRODUCTIVE TOXINS:
THIS PRODUCT DOES NOT CONTAIN ANY CHEMICALS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
INTERNATIONAL REGULATIONS: AS FOLLOWS
CANADIAN WHMIS:
THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH CONTROLLED PRODUCT
REGULATIONS EXCEPT FOR THE USE OF THE 16 HEADINGS.
WHMIS CLASS: CONSUMER COMMODITY
| 16. OTHER INFORMATION | |
REVISION DATE: 6/19/2015
SUPERSEDES DATE: 4/3/2012
REASON FOR REVISION: HAZCOM2012/GHS CONVERSION
DATASHEET PRODUCED BY: REGULATORY DEPARTMENT
HMIS RATINGS:
HEALTH 1
FLAMMABILITY 1
REACTIVITY 0
PERSONAL PROTECTION X
VOC LESS WATER LESS EXEMPT SOLVENT, G/L: 34.3
VOC MATERIAL, G/L: 19
VOC AS DEFINED BY CALIFORNIA CONSUMER PRODUCT REGULATION, WT/WT%: 0.1
TEXT FOR GHS HAZARD STATEMENTS SHOWN IN SECTION 3 DESCRIBING EACH
INGREDIENT:
H270: MAY CAUSE OR INTENSIFY FIRE; OXIDISER.
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
H331: TOXIC IF INHALED.
H332: HARMFUL IF INHALED.
ICONS FOR GHS PICTOGRAMS SHOWN IN SECTION 3 DESCRIBING EACH INGREDIENT:
GHS03: FLAME OVER CIRCLE
GHS06: SKULLS AND CROSSBONES
GHS07: EXCLAMATION MARK
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
DAP BELIEVES THE DATA AND STATEMENTS CONTAINED HEREIN ARE ACCURATE AS OF
THE DATE HEREOF. THEY ARE OFFERED IN GOOD FAITH AS TYPICAL VALUES AND NOT
AS A PRODUCT SPECIFICATION. NO WARRANTY OF MERCHANTABILITY, WARRANTY OF
FITNESS FOR ANY PARTICULAR PURPOSE OR ANY OTHER WARRANTY, EXPRESS OR
IMPLIED, IS MADE WITH REGARD TO THE INFORMATION HEREIN PROVIDED OR THE
PRODUCT TO WHICH THE INFORMATION REFERS. SINCE THIS DOCUMENT IS INTENDED
ONLY AS A GUIDE TO THE APPROPRIATE USE AND PRECAUTIONARY HANDLING OF THE
REFERENCED PRODUCT BY A PROPERLY TRAINED PERSON, IT IS THEREFORE THE
RESPONSIBILITY OF THE USER TO (I) REVIEW THE RECOMMENDATIONS WITH DUE
CONSIDERATION FOR THE SPECIFIC CONTEXT OF THE INTENDED USE AND (II)
DETERMINE IF THEY ARE APPROPRIATE.