| Common Name: | VINYL SPACKLING |
| Manufacturer: | DAP |
| SDS Revision Date: | 6/19/2015 |
| SDS Format: | GHS-US |
| Grainger Item Number(s): | 5E110 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SDS NUMBER: 00010405001
REVISION DATE: 6/19/2015
DAP(R*)
SAFETY DATA SHEET
24 HOUR EMERGENCY PHONE NUMBERS MEDICAL/POISON CONTROL:
IN U.S.: CALL 1-800-222-1222
OUTSIDE U.S.: CALL YOUR LOCAL POISON CONTROL CENTER
TRANSPORTATION/NATIONAL RESPONSE CENTER:
1-800-535-5053
1-352-323-3500
NOTE:
THE NATIONAL RESPONSE CENTER EMERGENCY NUMBERS TO BE USED ONLY IN THE EVENT
OF CHEMICAL EMERGENCIES INVOLVING A SPILL, LEAK, FIRE, EXPOSURE OR ACCIDENT
INVOLVING CHEMICALS.
IMPORTANT:
PROVIDE THIS INFORMATION TO EMPLOYEES, CUSTOMERS, AND USERS OF THIS PRODUCT
READ THIS SDS BEFORE HANDLING OR DISPOSING OF THIS PRODUCT. THIS PRODUCT IS
COVERED BY THE OSHA HAZARD COMMUNICATION STANDARD AND THIS DOCUMENT HAS BEEN
PREPARED IN ACCORDANCE WITH REQUIREMENTS OF THIS STANDARD. ALL ABBREVIATED
TERMS USED IN THIS MSDS ARE FURTHER DESCRIBED IN SECTION 16.
| 1. IDENTIFICATION |  |
THIS MATERIAL SAFETY DATA SHEET IS AVAILABLE IN AMERICAN SPANISH UPON
REQUEST.
PRODUCT NAME: VINYL SPACKLING
PRODUCT UPC NUMBER: 12130, 12132, 12133, 12008
PRODUCT USE/CLASS: SPACKLING COMPOUND
MANUFACTURER:
DAP PRODUCTS INC.
2400 BOSTON STREET SUITE 200
BALTIMORE, MD 21224-4723
888-327-8477 (NON - EMERGENCY MATTERS)
PREPARER: REGULATORY DEPARTMENT
REVISION DATE: 6/19/2015
SUPERSEDES DATE: 11/28/2011
SDS NO: 00010405001
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
PRODUCT DUST MAY BE IRRITATING TO EYES, SKIN AND RESPIRATORY SYSTEM. REMOVAL
OF THIS PRODUCT AFTER USE OR BY DRY SANDING WILL GENERATE DUST AND EXPOSURE
TO THIS DUST MAY BE IRRITATING TO THE EYES, EARS, NOSE AND MOUTH. MAY CAUSE
IRRITATION TO THE RESPIRATORY TRACT.
GHS CLASSIFICATION:
ACUTE TOX. 4 INHALATION, CARC. 1A, EYE IRRIT. 2, SKIN IRRIT. 2
SYMBOL(S) OF PRODUCT:
EXCLAMATION MARK
HEALTH HAZARD
SIGNAL WORD: DANGER
GHS HAZARD STATEMENTS:
SKIN IRRITATION, CATEGORY 2:
H315: CAUSES SKIN IRRITATION.
EYE IRRITATION, CATEGORY 2:
H319: CAUSES SERIOUS EYE IRRITATION.
ACUTE TOXICITY, INHALATION, CATEGORY 4:
H332: HARMFUL IF INHALED.
CARCINOGENICITY, CATEGORY 1A:
H350:
MAY CAUSE CANCER. CLASSIFIED AS CARCINOGENIC CATEGORY 1 ON THE BASIS OF
EPIDEMIOLOGICAL AND/OR ANIMAL DATA. MIXTURES ARE CLASSIFIED AS CARCINOGENIC
WHEN AT LEAST 1 INGREDIENT HAS BEEN CLASSIFIED AS CARCINOGENIC AND IS
PRESENT AT 0.1% OR ABOVE ROUTES OF EXPOSURE ARE DEPENDANT ON INGREDIENT
FORM.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
CHEMICAL NAME CAS-NO. WT. % GHS SYMBOLS GHS STATEMENTS
LIMESTONE 1317-65-3 50-75 GHS03 H270
QUARTZ 14808-60-7 0.1-1.0 GHS03-GHS07 H270-302
THE TEXT FOR GHS HAZARD STATEMENTS SHOWN ABOVE (IF ANY) IS GIVEN IN THE
"OTHER INFORMATION" SECTION.
| 4. FIRST-AID MEASURES | |
FIRST AID - INHALATION:
IF YOU EXPERIENCE DIFFICULTY IN BREATHING, LEAVE THE AREA TO OBTAIN FRESH
AIR. IF CONTINUED DIFFICULTY IS EXPERIENCED, GET MEDICAL ATTENTION
IMMEDIATELY.
FIRST AID - SKIN CONTACT:
WASH SKIN WITH SOAP AND WATER FOR 15 MINUTES. GET MEDICAL AID IF SYMPTOMS
PERSIST.
FIRST AID - EYE CONTACT:
IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH LARGE QUANTITIES OF WATER
FOR AT LEAST 15 MINUTES UNTIL IRRITATION SUBSIDES. GET MEDICAL ATTENTION
IMMEDIATELY.
FIRST AID - INGESTION:
IF SWALLOWED, DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION IMMEDIATELY.
| 5. FIRE-FIGHTING MEASURES | |
UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE KNOWN.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND (NIOSH APPROVED OR
EQUIVALENT) AND FULL PROTECTIVE GEAR. USE WATER SPRAY TO COOL EXPOSED
SURFACES.
EXTINGUISHING MEDIA: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG
| 6. ACCIDENTAL RELEASE MEASURES | |
ENVIRONMENTAL MEASURES: NO INFORMATION
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
IN CASE OF SPILLAGE, ABSORB WITH INERT MATERIAL AND DISPOSE OF IN ACCORDANCE
WITH APPLICABLE REGULATIONS.
| 7. HANDLING AND STORAGE | |
HANDLING:
KEEP OUT OF REACH OF CHILDREN!
DO NOT TAKE INTERNALLY. USE ONLY WITH ADEQUATE VENTILATION. ENSURE FRESH AIR
ENTRY DURING APPLICATION AND DRYING. DO NOT BREATHE DUST. REMOVAL OF THIS
PRODUCT AFTER USE WILL RESULT IN THE GENERATION OF DUST. IF DRY-SANDED,
EXPOSURE TO DUST MAY RESULT IN THE BUILD-UP OF MATERIAL IN EYES, EARS, NOSE,
AND MOUTH WHICH MAY CAUSE IRRITATION. WHILE DRY SANDING, USE OF A
NIOSH-APPROVED DUST MASK IS RECOMMENDED. WASH THOROUGHLY AFTER HANDLING.
STORAGE:
AVOID EXCESSIVE HEAT AND FREEZING. DO NOT STORE AT TEMPERATURES ABOVE 120
DEGREES F. STORE AWAY FROM CAUSTICS AND OXIDIZERS. KEEP CONTAINERS TIGHTLY
CLOSED.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
INGREDIENTS WITH OCCUPATIONAL EXPOSURE LIMITS:
CHEMICAL NAME ACGIH TLV-TWA ACGIH-TLV STEL OSHA PEL-TWA OSHA
PEL-CEILING
LIMESTONE N.E. N.E. 15 MG/M3 TWA N.E.
TOTAL DUST, 5 MG/M3
TWA RESPIRABLE
FRACTION
QUARTZ 0.025 MG/M3 N.E. N.E. N.E.
TWA RESPIRABLE
FRACTION
FURTHER ADVICE:
MEL = MAXIMUM EXPOSURE LIMIT
OES = OCCUPATIONAL EXPOSURE STANDARD
SUP = SUPPLIER'S RECOMMENDATION
SK = SKIN SENSITIZER
N.E. = NOT ESTABLISHED
PERSONAL PROTECTION:
RESPIRATORY PROTECTION:
WHEN CONCENTRATIONS EXCEED THE EXPOSURE LIMITS SPECIFIED, USE OF A
NIOSH-APPROVED DUST, MIST AND FUME RESPIRATOR IS RECOMMENDED. WHERE THE
PROTECTION FACTOR OF THE RESPIRATOR MAY BE EXCEEDED, USE OF A FULL
FACEPIECE,
SUPPLIED AIR, OR SELF CONTAINED BREATHING APPARATUS (SCBA) MAY BE NECESSARY.
IF CONCENTRATIONS EXCEED THE EXPOSURE LIMITS SPECIFIED, USE OF A
NIOSH-APPROVED SUPPLIED AIR RESPIRATOR IS RECOMMENDED. WHERE THE PROTECTION
FACTOR IS EXCEEDED, USE OF A SELF CONTAINED BREATHING APPARATUS (SCBA) MAY
BE NECESSARY. USE AN APPROVED NIOSH/OSHA RESPIRATOR IF DRY SANDED. NATIONAL
INSTITUTE FOR OCCUPATIONAL SAFETY AND HEALTH (NIOSH) HAS RECOMMENDED THAT
THE PERMISSIBLE EXPOSURE LIMIT BE CHANGED TO 50 MICROGRAMS RESPIRABLE FREE
SILICA PER CUBIC METER OF AIR (0.05 MG/M3) AS DETERMINED BY A FULL SHIFT
SAMPLE UP TO 10-HOUR WORK SHIFT. A RESPIRATORY PROTECTION PROGRAM THAT
MEETS THE OSHA 1910.134 AND ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED
WHENEVER WORKPLACE CONDITIONS WARRANT A RESPIRATOR'S USE.
SKIN PROTECTION: WEAR PROTECTIVE GLOVES.
EYE PROTECTION: SAFETY GLASSES WITH SIDE-SHIELDS.
OTHER PROTECTIVE EQUIPMENT: NOT REQUIRED UNDER NORMAL USE.
HYGIENIC PRACTICES: REMOVE AND WASH CONTAMINATED CLOTHING BEFORE RE-USE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: WHITE TO OFF-WHITE
ODOR: SLIGHT
DENSITY, G/CM3: 1.86 - 1.88
FREEZE POINT, DEG. C: NOT ESTABLISHED
SOLUBILITY IN WATER: NOT ESTABLISHED
DECOMPOSITION TEMPERATURE, DEG. C: NOT ESTABLISHED
BOILING RANGE, DEG. C: N.I. - N.I.
MINIMUM FLASH POINT, DEG. C: 93.3
EVAPORATION RATE: SLOWER THAN N-BUTYL ACETATE
VAPOR DENSITY: HEAVIER THAN AIR
COMBUSTIBILITY: DOES NOT SUPPORT COMBUSTION
PHYSICAL STATE: PASTE
ODOR THRESHOLD: NOT ESTABLISHED
PH: BETWEEN 7.0 AND 12.0
VISCOSITY (MPA.S): NOT ESTABLISHED
PARTITION COEFF., N-OCTANOL/WATER: NOT ESTABLISHED
EXPLOSIVE LIMITS, %: N.I. - N.I.
AUTO-IGNITION TEMPERATURE, DEG. C: NOT ESTABLISHED
VAPOR PRESSURE, MMHg: NO INFORMATION
FLASH METHOD: SETA CLOSED CUP
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
(IF PRODUCT IS AN AEROSOL, THE FLASH POINT STATED ABOVE IS THAT OF THE
PROPELLANT.)
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL CONDITIONS.
CONDITIONS TO AVOID:
DO NOT BREATHE DUST. AVOID DUST FORMATION IN CONFINED AREAS. EXCESSIVE HEAT
AND FREEZING.
INCOMPATIBILITY: INCOMPATIBLE WITH STRONG BASES AND OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NORMAL DECOMPOSITION PRODUCTS, I.E., COX, NOX.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECT OF OVEREXPOSURE - INHALATION:
INHALATION MAY CAUSE IRRITATION TO THE RESPIRATORY TRACT (NOSE, MOUTH,
MUCOUS MEMBRANES). PROLONGED, REPEATED, OR HIGH EXPOSURES MAY CAUSE
IRRITATION TO THE RESPIRATORY TRACT (NOSE, MOUTH, MUCOUS MEMBRANES DUST
FROM DRY SANDING MAY CAUSE EYE, SKIN, NOSE, THROAT AND RESPIRATORY TRACT
IRRITATION.
EFFECT OF OVEREXPOSURE - SKIN CONTACT:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEALTH EFFECTS. PROLONGED OR REPEATED CONTACT WITH SKIN MAY CAUSE MILD
IRRITATION. MAY CAUSE SKIN IRRITATION IN SUSCEPTIBLE PERSONS.
EFFECT OF OVEREXPOSURE - EYE CONTACT:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEAL EFFECTS. DIRECT EYE CONTACT MAY CAUSE IRRITATION. MAY CAUSE EYE
IRRITATION.
EFFECT OF OVEREXPOSURE - INGESTION:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEALTH EFFECTS. SINGLE DOSE ORAL TOXICITY IS VERY LOW. AMOUNTS INGESTED
INCIDENTAL TO INDUSTRIAL HANDLING ARE NOT LIKELY TO CAUSE INJURY; HOWEVER
INGESTION OF LARGE AMOUNTS MAY CAUSE INJURY. INGESTION MAY RESULT IN
OBSTRUCTION WHEN MATERIAL HARDENS.
CARCINOGENICITY: NO INFORMATION
PRIMARY ROUTE(S) OF ENTRY: EYE CONTACT INGESTION, INHALATION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
1317-65-3 LIMESTONE 6450 MG/KG RAT >2000 MG/KG >20 MG/L
14808-60-7 QUARTZ 500 MG/KG RAT >2000 MG/KG >20 MG/L
N.I. = NO INFORMATION
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION:
ECOLOGICAL INJURIES ARE NOT KNOWN OR EXPECTED UNDER NORMAL USE.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
THIS PRODUCT DOES NOT MEET THE DEFINITION OF A HAZARDOUS WASTE ACCORDING TO
U.S. EPA HAZARDOUS WASTE MANAGEMENT REGULATION, 40 CFR SECTION 261. DISPOSE
AS HAZARDOUS WASTE ACCORDING TO ALL LOCAL, STATE, FEDERAL AND PROVINCIAL
REGULATIONS. STATE AND LOCAL REGULATIONS/RESTRICTIONS ARE COMPLEX AND MAY
DIFFER FROM FEDERAL REGULATIONS. RESPONSIBILITY FOR PROPER WASTE DISPOSAL IS
WITH THE OWNER OF THE WASTE.
| 14. TRANSPORT INFORMATION | |
SPECIAL TRANSPORT PRECAUTIONS: NO INFORMATION
DOT UN/NA NUMBER: N.A.
DOT PROPER SHIPPING NAME: NOT REGULATED.
DOT TECHNICAL NAME: N.A.
DOT HAZARD CLASS: N.A.
HAZARD SUBCLASS: N.A.
PACKING GROUP: N.A.
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
ACUTE HEALTH HAZARD, CHRONIC HEALTH HAZARD
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
NO SARA 313 COMPONENTS EXIST IN THIS PRODUCT.
TOXIC SUBSTANCES CONTROL ACT:
ALL INGREDIENTS IN THIS PRODUCT ARE EITHER ON TSCA INVENTORY LIST, OR
OTHERWISE EXEMPT.
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
NO TSCA 12(B) COMPONENTS EXIST IN THIS PRODUCT.
CALIFORNIA PROPOSITION 65 CARCINOGENS:
WARNING:
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
CALIFORNIA PROPOSITION 65 REPRODUCTIVE TOXINS:
THIS PRODUCT DOES NOT CONTAIN ANY CHEMICALS KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
INTERNATIONAL REGULATIONS: AS FOLLOWS -
CANADIAN WHMIS:
THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH CONTROLLED PRODUCT
REGULATIONS EXCEPT FOR THE USE OF THE 16 HEADINGS.
WHMIS CLASS: CONSUMER COMMODITY
| 16. OTHER INFORMATION | |
REVISION DATE: 6/19/2015
SUPERSEDES DATE: 11/28/2011
REASON FOR REVISION: HAZCOM2012/GHS CONVERSION
DATASHEET PRODUCED BY: REGULATORY DEPARTMENT
HMIS RATINGS:
HEALTH 1
FLAMMABILITY 1
REACTIVITY 0
PERSONAL PROTECTION X
VOC LESS WATER LESS EXEMPT SOLVENT, G/L: 40.6
VOC MATERIAL, G/L: 23
VOC AS DEFINED BY CALIFORNIA CONSUMER PRODUCT REGULATION, WT/WT%: 0.3
TEXT FOR GHS HAZARD STATEMENTS SHOWN IN SECTION 3 DESCRIBING EACH
INGREDIENT:
H270: MAY CAUSE OR INTENSIFY FIRE; OXIDIZER.
H302: HARMFUL IF SWALLOWED.
ICONS FOR GHS PICTOGRAMS SHOWN IN SECTION 3 DESCRIBING EACH INGREDIENT:
GHS03: FLAME OVER CIRCLE
GHS07: EXCLAMATION MARK
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
DAP BELIEVES THE DATA AND STATEMENTS CONTAINED HEREIN ARE ACCURATE AS OF THE
DATE HEREOF. THEY ARE OFFERED IN GOOD FAITH AS TYPICAL VALUES AND NOT AS A
PRODUCT SPECIFICATION. NO WARRANTY OF MERCHANTABILITY, WARRANTY OF FITNESS
FOR ANY PARTICULAR PURPOSE OR ANY OTHER WARRANTY, EXPRESS OR IMPLIED, IS
MADE WITH REGARD TO THE INFORMATION HEREIN PROVIDED OR THE PRODUCT TO WHICH
THE INFORMATION REFERS. SINCE THIS DOCUMENT IS INTENDED ONLY AS A GUIDE TO
THE APPROPRIATE USE AND PRECAUTIONARY HANDLING OF THE REFERENCED PRODUCT BY
A PROPERLY TRAINED PERSON, IT IS THEREFORE THE RESPONSIBILITY OF THE USER
TO (I) REVIEW THE RECOMMENDATIONS WITH DUE CONSIDERATION FOR THE SPECIFIC
CONTEXT OF THE INTENDED USE AND (II) DETERMINE IF THEY ARE APPROPRIATE.