| Common Name: | LOCTITE MR GS2 GASKET SEALANT KNOWN AS LOCTITE GS 2 3OZ EN, 30514 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 8/6/2014 |
| SDS Format: | GHS-US |
| Grainger Item Number(s): | 2EMY2, 5A239 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
HENKEL
REVISION NUMBER: 004.0
ISSUE DATE: 08/06/2014
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME: LOCTITE MR GS2 GASKET SEALANT KNOWN AS LOCTITE GS #2 3OZ EN
IDH NUMBER: 234891
PRODUCT TYPE: SEALANT
ITEM NUMBER: 30514
RESTRICTION OF USE: NONE IDENTIFIED
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER: 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
DANGER:
CAUSES SKIN IRRITATION.
MAY CAUSE AN ALLERGIC SKIN REACTION.
CAUSES SERIOUS EYE DAMAGE.
MAY CAUSE ALLERGY OR ASTHMA SYMPTOMS OR BREATHING DIFFICULTIES IF INHALED.
HAZARD CLASS HAZARD CATEGORY
SKIN IRRITATION 2
SERIOUS EYE DAMAGE 1
RESPIRATORY SENSITIZATION 1
SKIN SENSITIZATION 1
PICTOGRAM(S):
HEALTH HAZARD
CORROSION
PRECAUTIONARY STATEMENTS:
PREVENTION:
AVOID BREATHING DUST OR FUMES. WASH THOROUGHLY AFTER HANDLING. CONTAMINATED
WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE. WEAR EYE AND FACE
PROTECTION. WEAR PROTECTIVE GLOVES. IN CASE OF INADEQUATE VENTILATION WEAR
RESPIRATORY PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
IF INHALED:
IF BREATHING IS DIFFICULT, REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A
POSITION COMFORTABLE FOR BREATHING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO REMOVE. CONTINUE RINSING. IMMEDIATELY CALL A POISON
CONTROL CENTER OR PHYSICIAN.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ATTENTION.
IF EXPERIENCING RESPIRATORY SYMPTOMS:
CALL A POISON CENTER OR PHYSICIAN. TAKE OFF CONTAMINATED CLOTHING.
STORAGE: NOT PRESCRIBED
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER ACCORDING TO FEDERAL, STATE/PROVINCIAL
AND LOCAL GOVERNMENTAL REGULATIONS.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD (29 CFR
1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE UNITED NATIONS
GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF CHEMICALS
(GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
KAOLIN 1332-58-7 30 - 60
CASTOR OIL, OXIDIZED 68187-84-8 10 - 30
ROSIN 8050-09-7 10 - 30
METHYL ACETATE 79-20-9 10 - 30
TITANIUM DIOXIDE 13463-67-7 1 - 5
QUARTZ (SiO2) 14808-60-7 0.1 - 1
CARBON BLACK 1333-86-4 0.1 - 1
* EXACT PERCENTAGE IS A TRADE SECRET. CONCENTRATION RANGE IS PROVIDED TO
ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
SKIN CONTACT:
IMMEDIATELY FLUSH SKIN WITH PLENTY OF WATER (USING SOAP, IF AVAILABLE).
REMOVE CONTAMINATED CLOTHING AND FOOTWEAR. WASH CLOTHING BEFORE REUSE. GET
MEDICAL ATTENTION.
EYE CONTACT:
RINSE IMMEDIATELY WITH PLENTY OF WATER, ALSO UNDER THE EYELIDS, FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. GET MEDICAL ATTENTION.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
WATER SPRAY (FOG), FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING, SUCH
AS TURN-OUT GEAR.
UNUSUAL FIRE OR EXPLOSION HAZARDS:
UNCONTROLLED POLYMERIZATION MAY OCCUR AT HIGH TEMPERATURES RESULTING IN
EXPLOSIONS OR RUPTURE OF STORAGE CONTAINERS. IN CASE OF FIRE, KEEP
CONTAINERS COOL WITH WATER SPRAY.
HAZARDOUS COMBUSTION PRODUCTS:
ALDEHYDES. OXIDES OF CARBON. CARBOXYLIC ACIDS. IRRITATING VAPOURS.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW PRODUCT TO ENTER SEWER OR WATERWAYS.
CLEAN-UP METHODS:
REMOVE ALL SOURCES OF IGNITION. EVACUATE AND VENTILATE SPILL AREA; DIKE
SPILL TO PREVENT ENTRY INTO WATER SYSTEM; WEAR FULL PROTECTIVE EQUIPMENT
DURING CLEAN-UP. SOAK UP WITH INERT ABSORBENT MATERIAL (E.G. SAND, SILICA
GEL, ACID BINDER, UNIVERSAL BINDER, SAWDUST). SCRAPE UP SPILLED MATERIAL
AND PLACE IN A CLOSED CONTAINER FOR DISPOSAL. REFER TO SECTION 8 "EXPOSURE
CONTROLS / PERSONAL PROTECTION" PRIOR TO CLEAN UP.
| 7. HANDLING AND STORAGE | |
HANDLING:
USE ONLY WITH ADEQUATE VENTILATION. PREVENT CONTACT WITH EYES, SKIN AND
CLOTHING. DO NOT BREATHE VAPOR AND MIST. WASH THOROUGHLY AFTER HANDLING.
REFER TO SECTION 8.
STORAGE:
KEEP IN A COOL, WELL VENTILATED AREA AWAY FROM HEAT, SPARKS AND OPEN FLAME.
KEEP CONTAINER TIGHTLY CLOSED UNTIL READY FOR USE.
FOR INFORMATION ON PRODUCT SHELF LIFE CONTACT HENKEL CUSTOMER SERVICE AT
(800) 243-4874.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE THE
NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL AIHA WEEL OTHER
KAOLIN 2 MG/M3 TWA 15 MG/M3 PEL NONE NONE
RESPIRABLE TOTAL DUST.
FRACTION.
5 MG/M3 PEL
RESPIRABLE
FRACTION.
CASTOR OIL, OXIDIZED NONE NONE NONE NONE
ROSIN EXPOSURE BY NONE NONE NONE
ALL ROUTES
SHOULD BE
CAREFULLY
CONTROLLED
TO LEVELS AS
LOW AS
POSSIBLE.
INCLUDED IN
THE
REGULATION
BUT WITH NO
DATA VALUES.
SEE
REGULATION
FOR FURTHER
DETAILS
METHYL ACETATE 200 PPM TWA 200 PPM NONE NONE
250 PPM STEL (610 MG/M3)
PEL
TITANIUM DIOXIDE 10 MG/M3 TWA 15 MG/M3 PEL NONE NONE
TOTAL DUST.
QUARTZ (SiO2) 0.025 MG/M3 2.4 MPPCF TWA NONE NONE
TWA RESPIRABLE.
RESPIRABLE
FRACTION. 0.1 MG/M3 TWA
RESPIRABLE.
0.3 MG/M3 TWA
TOTAL DUST.
CARBON BLACK 3 MG/M3 TWA 3.5 MG/M3 PEL NONE NONE
INHALABLE
FRACTION.
ENGINEERING CONTROLS:
PROVIDE ADEQUATE LOCAL EXHAUST VENTILATION TO MAINTAIN WORKER EXPOSURE
BELOW EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE A NIOSH APPROVED SUPPLIED AIR RESPIRATOR IF THE POTENTIAL TO EXCEED
ESTABLISHED EXPOSURE LIMITS EXISTS.
EYE/FACE PROTECTION:
SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS. FULL FACE PROTECTION
SHOULD BE USED IF THE POTENTIAL FOR SPLASHING OR SPRAYING OF PRODUCT
EXISTS. SAFETY SHOWERS AND EYE WASH STATIONS SHOULD BE AVAILABLE.
SKIN PROTECTION:
USE CHEMICAL RESISTANT, IMPERMEABLE CLOTHING INCLUDING GLOVES AND EITHER AN
APRON OR BODY SUIT TO PREVENT SKIN CONTACT. BUTYL RUBBER GLOVES. NEOPRENE
GLOVES.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: PASTE
COLOR: BLACK
ODOR: ESTER-LIKE
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
BOILING POINT/RANGE: NOT AVAILABLE.
MELTING POINT/ RANGE: NOT AVAILABLE.
SPECIFIC GRAVITY: 1.55 AT 25 DEG. C (77 DEG. F)
VAPOR DENSITY: NOT AVAILABLE.
FLASH POINT: PRODUCT IS A SOLID. (ASTM D 4359)
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT DETERMINED
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT DETERMINED
AUTOIGNITION TEMPERATURE: NOT AVAILABLE.
EVAPORATION RATE: NOT AVAILABLE.
SOLUBILITY IN WATER: PARTIALLY SOLUBLE
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: 0.3%; 4.65 G/L
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL CONDITIONS OF STORAGE AND USE.
HAZARDOUS REACTIONS: NONE UNDER NORMAL PROCESSING.
HAZARDOUS DECOMPOSITION PRODUCTS:
OXIDES OF CARBON. ALDEHYDES. CARBOXYLIC ACIDS. IRRITATING VAPOURS.
INCOMPATIBLE MATERIALS:
STRONG OXIDIZING AGENTS. AMINES. AMMONIA. STRONG ACIDS. SULFURIC ACID.
NITRIC ACID.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID:
HEAT, FLAMES, SPARKS AND OTHER SOURCES OF IGNITION. STORE AWAY FROM
INCOMPATIBLE MATERIALS. ELEVATED TEMPERATURES.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES, INGESTION
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION:
MAY CAUSE ALLERGIC RESPIRATORY REACTION. THESE SYMPTOMS, WHICH CAN INCLUDE
CHEST TIGHTNESS, WHEEZING, COUGH, SHORTNESS OF BREATH OR ASTHMA ATTACK,
COULD BE IMMEDIATE OR DELAYED (UP TO SEVERAL HOURS AFTER EXPOSURE). MAY
CAUSE IRRITATION TO NOSE AND THROAT.
SKIN CONTACT: CAUSES SKIN IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SERIOUS EYE DAMAGE.
INGESTION:
MAY CAUSE IRRITATION TO THE GASTROINTESTINAL TRACT, MOUTH AND MUCOUS
MEMBRANES.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED HEALTH
EFFECTS
KAOLIN ORAL LD50 (RAT): NUISANCE DUST
>5,000 MG/KG
DERMAL LD50 (RAT):
>5,000 MG/KG
CASTOR OIL, OXIDIZED NONE NO RECORDS
ROSIN NONE ALLERGEN, IRRITANT,
RESPIRATORY
METHYL ACETATE ORAL LD50 (RABBIT): BLOOD, CENTRAL NERVOUS
3.7 G/KG SYSTEM, EYES, IRRITANT
TITANIUM DIOXIDE NONE IRRITANT, RESPIRATORY, SOME
EVIDENCE OF CARCINOGENICITY
QUARTZ (SiO2) NONE IMMUNE SYSTEM, LUNG, SOME
EVIDENCE OF CARCINOGENICITY
CARBON BLACK ORAL LD50 (RAT): RESPIRATORY, SOME EVIDENCE
>8,000 MG/KG OF CARCINOGENICITY
HAZARDOUS COMPONENT(S) NTP CARCINOGEN IARC CARCINOGEN OSHA CARCINOGEN
(SPECIFICALLY
REGULATED)
KAOLIN NO NO NO
CASTOR OIL, OXIDIZED NO NO NO
ROSIN NO NO NO
METHYL ACETATE NO NO NO
TITANIUM DIOXIDE NO GROUP 2B NO
QUARTZ (SiO2) KNOWN TO BE GROUP 1 NO
HUMAN
CARCINOGEN.
CARBON BLACK NO GROUP 2B NO
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
HAZARDOUS WASTE NUMBER: NOT A RCRA HAZARDOUS WASTE.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES TO THE
MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY
PACKAGE/CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED OR ARE EXEMPT FROM LISTING ON THE TOXIC
SUBSTANCES CONTROL ACT INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION: BLOWN CASTOR OIL (CAS# 68187-84-8).
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313: NONE ABOVE REPORTING DE MINIMIS
CERCLA REPORTABLE QUANTITY:
METHYL ACETATE (CAS# 79-20-9): 100 LBS. (45.4 KG)
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN IN THE STATE OF CALIFORNIA TO CAUSE
CANCER. THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
ALL COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE CANADIAN
DOMESTIC SUBSTANCES LIST.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: NEW SAFETY DATA SHEET FORMAT.
PREPARED BY: SHEILA GINES, REGULATORY AFFAIRS SPECIALIST
ISSUE DATE: 08/06/2014
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR ANY
PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND TO ADOPT
SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF PROPERTY AND
PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE HANDLING AND USE OF
ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING, HENKEL SPECIFICALLY
DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARISING FROM SALE OR
USE OF HENKEL'S PRODUCTS. HENKEL FURTHER DISCLAIMS ANY LIABILITY FOR
CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND, INCLUDING LOST PROFITS.